HCPL-0302 Electronic IC Chip Output Current IGBT Gate Drive Optocoupler
electronic integrated circuit
,linear integrated circuits
HCPL-3020/HCPL-0302
0.4 Amp Output Current IGBT Gate Drive Optocoupler
Description
The HCPL-3020 and HCPL-0302 consist of a GaAsP LED optically coupled to an integrated circuit with a power output stage. These optocouplers are ideally suited for driving power IGBTs and MOSFETs used in motor control inverter applications. The high operating voltage range of the output stage provides the drive voltages required by gate-controlled devices. The voltage and current supplied by this optocoupler makes it ideally suited for directly driving small or medium power IGBTs. For IGBTs with higher ratings, the HCPL-0314/3140 (0.6 A), HCPL-3150 (0.6 A) or HCPL-3120 (2.5 A) gate drive opto-couplers can be used.
Features
• 0.4 A maximum peak output current
• 0.2 A minimum peak output current
• High speed response: 0.7 µs maximum propagation delay over temperature range
• Ultra high CMR: minimum 10 kV/µs at VCM = 1000 V
• Bootstrappable supply current: maximum 3 mA
• Wide operating temperature range: –40°C to 100°C
• Wide VCC operating range: 10 V to 30 V over temperature range
• Available in DIP 8 and SO-8 packages
• Safety approvals: UL approval, 3750 VRMS for 1 minute
• CSA approval
• IEC/EN/DIN EN 60747-5-2 approval
VIORM = 630 VPEAK (HCPL-3020),
VIORM = 566 VPEAK (HCPL-0302)
Applications
• Isolated IGBT/power MOSFET gate drive
• AC and brushless DC motor drives
• Industrial inverters
• Air conditioner
• Washing machine
• Induction heater for cooker
• Switching power supplies (SPS)
Functional Diagram
Absolute Maximum Ratings
Parameter | Symbol | Min. | Max. | Units | Note |
---|---|---|---|---|---|
Storage Temperature | TS | -55 | 125 | °C | |
Operating Temperature | TA | -40 | 100 | °C | |
Average Input Current | IF(AVG) | 20 | mA | 1 | |
Peak Transient Input Current (<1 µs pulse width, 300 pps) |
IF(TRAN) | 1.0 | A | ||
Reverse Input Voltage | VR | 5 | V | ||
“High” Peak Output Current | IOH(PEAK) | 0.4 | A | 2 | |
“Low” Peak Output Current | IOL(PEAK) | 0.4 | A | 2 | |
Supply Voltage | VCC – VEE | –0.5 | 35 | V | |
Output Voltage | VO(PEAK) | –0.5 | VCC | V | |
Output Power Dissipation | PO | 250 | mW | 3 | |
Input Power Dissipation | PI | 45 | mW | 4 | |
Lead Solder Temperature | 260°C for 10 sec., 1.6 mm below seating plane | ||||
Solder Reflow Temperature Profile | See Package Outline Drawings section |
Notes:
1. Derate linearly above 70°C free air temperature at a rate of 0.3 mA/°C.
2. Maximum pulse width = 10 µs, maximum duty cycle = 0.2%. This value is intended to allow for component tolerances for designs with IO peak minimum = 0.2 A. See Application section for additional details on limiting IOL peak.
3. Derate linearly above 85°C, free air temperature at the rate of 4.0 mW/°C.
4. Input power dissipation does not require derating.
Stock Offer (Hot Sell)
Part No. | Quantity | Brand | D/C | Package |
VND5E050AKTR-E | 3314 | ST | 15+ | SSOP-24 |
VND5N07 | 7988 | ST | 13+ | TO-252 |
VS1003B-L | 4658 | VLSI | 16+ | QFP48 |
VS1063A-L | 1844 | VLSI | 16+ | LQFP-48 |
VS-10MQ100NPBF | 93000 | VISHAY | 15+ | SMA |
VS-6CWQ06FNPBF | 13207 | VISHAY | 13+ | TO-252 |
VSLB3940 | 15550 | VISHAY | 10+ | DIP-2 |
W25Q128FVFG | 17585 | WINBOND | 15+ | SOP-16 |
W25Q128FVPIQ | 17798 | WINBOND | 16+ | WSON-8 |
W25Q16DVSSIG | 6761 | WINBOND | 16+ | SOP-8 |
W25Q256FVFIG | 11408 | WINBOND | 13+ | SOP-16 |
W25X10CLUXIG | 15621 | WINBOND | 14+ | USON8 |
W25X40BVSNIG | 44000 | WINBOND | 12+ | SOP-8 |
W25X40CLSNIG | 5543 | WINBOND | 16+ | SOP-8 |
W27C010-70Z | 4624 | WINBOND | 13+ | DIP-32 |
W5300 | 2858 | WIZNET | 16+ | LQFP-100 |
W78E516B40DL | 11479 | WINBOND | 13+ | DIP-40 |
WD37C65CJM | 4872 | WDC | 16+ | PLCC44 |
WF19054 | 4823 | WINBOND | 01+ | DIP-40 |
WS6264LLPG-70 | 3285 | WINGSHING | 13+ | DIP-28 |
X2444P | 7795 | XICOR | 11+ | DIP-8 |
X28C256P-15 | 6438 | XICOR | 14+ | DIP-28 |
X28HC64JI-12 | 7780 | XICOR | 14+ | PLCC32 |
X5043PIZ | 4354 | INTERSIL | 16+ | DIP-8 |
X9C103PIZ | 3597 | INTERSIL | 16+ | DIP-8 |
X9C104SIZ | 4793 | INTERSIL | 16+ | SOP-8 |
XC2C64A-7VQG44C | 2618 | XILINX | 12+ | QFP |
XC3S200AN-4FT256C | 2632 | XILINX | 15+ | BGA |
XC3S250E-4PQG208C | 2837 | XILINX | 15+ | QFP208 |
XC3S500E-4PQG208C | 1903 | XILINX | 15+ | QFP208 |
0402 0.063W 10kOhm SMT Thick Film Chip Resistor RC0402JR-0710KL
200MHz MPZ1608S300ATAH0 Chip Beads 5A For Power Line TDK SMD0603
22R 5% SMD0402 Film Chip Resistors ERJ-2GEJ220X PANASONIC
MOV-20D751K 750V 6.5kA Varistor blue SMD Chip Resistor 1 Circuit Through Hole Disc 20mm
2SB1261-TP 10W General Purpose Rectifier Diode Silicon Epitaxial Planar Pnp Transistor
IXFK140N30P Polar Power Mosfet Hiperfet TO264 300V 140A
DF2B29FU,H3F TVS 24VWM 47V ESD Protection Diodes
PMEG6010ER 1A Low VF MEGA Schottky Barrier Rectifier SOD123
SK34SMA 3A SMD Schottky Barrier Rectifier Diodes DO - 214AC
SMBJ5.0A Silicon Avalanche Diodes 600W Surface Mount TVS Diodes
Image | Part # | Description | |
---|---|---|---|
0402 0.063W 10kOhm SMT Thick Film Chip Resistor RC0402JR-0710KL |
10 kOhms ±5% 0.063W, 1/16W Chip Resistor 0402 (1005 Metric) Moisture Resistant Thick Film
|
||
200MHz MPZ1608S300ATAH0 Chip Beads 5A For Power Line TDK SMD0603 |
30 Ohms 1 Power Line Ferrite Bead 0603 (1608 Metric) 5A 10mOhm
|
||
22R 5% SMD0402 Film Chip Resistors ERJ-2GEJ220X PANASONIC |
22 Ohms ±5% 0.1W, 1/10W Chip Resistor 0402 (1005 Metric) Automotive AEC-Q200 Thick Film
|
||
MOV-20D751K 750V 6.5kA Varistor blue SMD Chip Resistor 1 Circuit Through Hole Disc 20mm |
750 V 6.5 kA Varistor 1 Circuit Through Hole Disc 20mm
|
||
2SB1261-TP 10W General Purpose Rectifier Diode Silicon Epitaxial Planar Pnp Transistor |
Bipolar (BJT) Transistor PNP 60 V 3 A 50MHz 1 W Surface Mount D-Pak
|
||
IXFK140N30P Polar Power Mosfet Hiperfet TO264 300V 140A |
N-Channel 300 V 140A (Tc) 1040W (Tc) Through Hole TO-264AA (IXFK)
|
||
DF2B29FU,H3F TVS 24VWM 47V ESD Protection Diodes |
47V Clamp 3A (8/20µs) Ipp Tvs Diode Surface Mount USC
|
||
PMEG6010ER 1A Low VF MEGA Schottky Barrier Rectifier SOD123 |
Diode 60 V 1A Surface Mount SOD-123W
|
||
SK34SMA 3A SMD Schottky Barrier Rectifier Diodes DO - 214AC |
Diode 40 V 3A Surface Mount DO-214AC, SMA
|
||
SMBJ5.0A Silicon Avalanche Diodes 600W Surface Mount TVS Diodes |
9.2V Clamp 65.3A Ipp Tvs Diode Surface Mount DO-214AA (SMBJ)
|